高道星,豆斌林,张华,罗川奇,杜金博
GAO Daoxing,DOU Binlin,ZHANG Hua,LUO Chuanqi,DU Jinbo

• 1:上海理工大学能源与动力工程学院

摘要(Abstract)：

采用载氧体催化剂化学链直接分解水一步制纯氢，并将其与生物质热转化耦合，开发具有应用前景和经济性的制氢同时制合成气的新方法具有重要意义。探究金属螯合溶胶-凝胶方法制备掺杂Ce-Ni的铁基载氧体，以化学链水分解耦合乙酸热分解方式制取纯氢和富氢合成气，首先在氧化态载氧体作用下，乙酸催化热分解制取富氢合成气，载氧体被还原，实现了载氧体晶格氧的迁移，通过原位CO_2吸附实现热分解过程强化；其次是利用还原态载氧体与水发生铁-蒸汽过程制氢。研究发现，在乙酸催化热分解过程进行原位CO_2吸附强化，提高了合成气H_2纯度并减少积碳。与无掺杂纯氧化铁与空白石英砂对照，掺杂适量的Ce与Ni的Fe基载氧体具有显著制氢作用，随Ce、Ni量增加，乙酸分解阶段CO_2和CO生成量减少，水分解阶段H_2先增后降，最佳载氧体Fe、Ce和Ni组分物质的量比为100∶10∶3,加入相对于载氧体不同质量比的CO_2吸附剂均可有效降低合成气中CO_2与CO气体量，最佳质量比为1∶2,在该条件下合成气中H_2体积分数提高了11.96%～26.17%,CO_2体积分数减少了22.85%～49.28%,CO体积分数减少了29.18%～34.05%,15次循环后载氧体仍保持较好的稳定性。
It is of great significance to develop a new method for hydrogen production and syngas production that utilizes oxygen carrier catalysts to directly decompose water to produce pure hydrogen in one stepand couple it with biomass thermal conversion. Iron-based oxygen carriers doped with Ce-Ni were prepared by metal chelating sol-gel method. Pure hydrogen and hydrogen-rich synthesis gas were prepared by chemical looping water decomposition coupled with acetic acid thermal decomposition. Firstly, under the action of oxidized oxygen carriers, acetic acid catalyzed thermal decomposition to produce hydrogen-rich syngas. And the oxygen carrier was reduced to realize the migration of lattice oxygen in the oxygen carrier, and the thermal decomposition process was strengthened by in-situ CO_2 adsorption. Secondly, hydrogen production was achieved through the iron steam process using the reduced oxygen carrier with water. It is found that the in-situ CO_2 adsorption is enhanced during the catalytic thermal decomposition of acetic acid, which can improve the purity of H_2 in syngas and reduce carbon deposition. Compared with undoped pure iron oxide and blank quartz samples, the Fe-based oxygen carrier doped with appropriate amount of Ce and Ni has obvious hydrogen production effect. With the increase of Ce and Ni, the amount of CO_2 and CO produced in the acetic acid decomposition stage decrease, while H_2 increases firstly and then decreases during water decomposition. The optimum molar ratio of oxygen carrier Fe, Ce and Ni is 100∶10∶3.The addition of CO_2 adsorbent with different mass ratio of oxygen carrier can effectively reduce the amount of CO_2 and CO in syngas, and the best mass ratio is 1∶2.Under this condition, the syngas composition of H_2 is increased by 11.96%-26.17%, CO_2 is reduced by 22.85%-49.28%, CO is reduced by 29.18%-34.05%, and the oxygen carriers remain good stability after 15 cycles.

关键词(KeyWords)： 金属螯合溶胶-凝胶法;化学链水分解制氢;CO_2吸附剂;乙酸热分解;合成气
metal-chelated sol-gel method;hydrogen production by chemical looping water decomposition;CO_2 adsorbent;thermal decomposition of acetic acid;synthesis gas

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金资助项目(51876130)

作者(Author): 高道星,豆斌林,张华,罗川奇,杜金博
GAO Daoxing,DOU Binlin,ZHANG Hua,LUO Chuanqi,DU Jinbo

DOI: 10.13226/j.issn.1006-6772.CN22121401

参考文献(References)：

• [1] LEVIN D B,CHAHINE R.Challenges for renewable hydrogen production from biomass[J].International Journal of Hydrogen Energy,2010,35(10):4962-4969.
• [2] ISHAQ H,DINCER I,CRAWFORD C.A review on hydrogen production and utilization:Challenges and opportunities[J].International Journal of Hydrogen Energy,2022,47(62):26238-26264.
• [3] 徐连兵.我国氢能源利用前景与发展战略研究[J].洁净煤技术，2022,28(9):1-10.XU Lianbing.Research on the prospect and development strategy of hydrogen energy in China [J].Clean Coal Technology,2022,28(9):1-10.
• [4] CHAI S,ZHANG G,LI G,et al.Industrial hydrogen production technology and development status in China:A review[J].Clean Technologies and Environmental Policy,2021,23(7):1931-1946.
• [5] YAN C F,HU E Y,CAI C L.Hydrogen production from bio-oil aqueous fraction with in situ carbon dioxide capture[J].International Journal of Hydrogen Energy,2010,35(7):2612-2616.
• [6] DING H,XU Y,LUO C,et al.A novel composite perovskite-based material for chemical-looping steam methane reforming to hydrogen and syngas[J].Energy Conversion and Management,2018,171:12-19.
• [7] NAHAR G,DUPONT V,TWIGG M V,et al.Feasibility of hydrogen production from steam reforming of biodiesel (FAME) feedstock on Ni-supported catalysts[J].Applied Catalysis B:Environmental,2015,168/169:228-242.
• [8] TAIPABU M I,VISWANATHAN K,WU W,et al.A critical review of the hydrogen production from biomass-based feedstocks:Challenge,solution,and future prospect[J].Process Safety and Environmental Protection,2022,164:384-407.
• [9] VUPPALADADIYAM A K,VUPPALADADIYAM S S V,AWASTHI A,et al.Biomass pyrolysis:A review on recent advancements and green hydrogen production[J].Bioresour Technol,2022,364:128087.
• [10] 单明玄，王坤，杨美玲，等.蒸气重整轻质生物油催化制氢研究进展[J] 洁净煤技术，2022,28(7):120-133.SHAN Mingxuan,WANG Kun,YANG Meiling.Research progress on catalytic hydrogen production based on steam reforming of light bio-oil [J].Clean Coal Technology,2022,28(7):120-133.
• [11] POLLARD A S,ROVER M R,BROWN R C.Characterization of bio-oil recovered as stage fractions with unique chemical and physical properties[J].Journal of Analytical and Applied Pyrolysis,2012,93:129-138.
• [12] CALLES J A,CARRERO A,VIZCAíno A J,et al.Agglomerated Co-Cr/SBA-15 catalysts for hydrogen production through acetic acid steam reforming[J].International Journal of Hydrogen Energy,2020,45(32):15941-15950.
• [13] MESSERSCHMITT A.Process of producing hydrogen:US971206[P].1910-09-27.
• [14] HUA X,FAN Y,WANG Y,et al.The behaviour of multiple reaction fronts during iron (III) oxide reduction in a non-steady state packed bed for chemical looping water splitting[J].Applied Energy,2017,193:96-111.
• [15] HOSSEINI S Y,KHOSRAVI-NIKOU M R,SHARIATI A.Production of hydrogen and syngas using chemical looping technology via cerium-iron mixed oxides[J].Chemical Engineering and Processing:Process Intensification,2019,139:23-33.
• [16] ROSLAN N A,ABIDIN S Z,IDERIS A,et al.A review on glycerol reforming processes over Ni-based catalyst for hydrogen and syngas productions[J].International Journal of Hydrogen Energy,2020,45(36):18466-18489.
• [17] ESTEBAN-DíEZ G,GIL M V,PEVIDA C,et al.Effect of operating conditions on the sorption enhanced steam reforming of blends of acetic acid and acetone as bio-oil model compounds[J].Applied Energy,2016,177:579-590.
• [18] GIL M V,FERMOSO J,PEVIDA C,et al.Production of fuel-cell grade H2 by sorption enhanced steam reforming of acetic acid as a model compound of biomass-derived bio-oil[J].Applied Catalysis B:Environmental,2016,184:64-76.
• [19] LUO C,DOU B,ZHANG H,et al.Hydrogen and syngas co-production by coupling of chemical looping water splitting and glycerol oxidation reforming using Ce-Ni modified Fe-based oxygen carriers[J].Journal of Cleaner Production,2022,335:130299.
• [20] DOU B,ZHANG H,CUI G,et al.Hydrogen production by sorption-enhanced chemical looping steam reforming of ethanol in an alternating fixed-bed reactor:Sorbent to catalyst ratio dependencies[J].Energy Conversion and Management,2018,155:243-252.