罗化峰
LUO Huafeng

• 1:山西大同大学煤炭工程学院

摘要(Abstract)：

为满足煤制油工业化过程中设计和操作需要,以H_2在神华煤液化油模型组分混合溶剂中实测溶解度为基础,考察利用人工神经网络法预测H_2在该系统中溶解度的能力。结果表明,神经网络的计算精度随着循环次数的增加而提高;对于不同种类的混合溶剂,随着隐藏层个数的增加,计算值与试验值之间的相对误差呈现逐渐减小的趋势,从减小计算量的角度考虑,选定为4个隐藏层;3-4-1网络结构对于H_2在不同混合溶剂中溶解度的计算值与试验值最大相对误差为4.48%,这表明该模型能够满足H_2在该系统中溶解度的预测需要。
In order to meet the requirement of design and operation during coal oil industrialization,the practical H_2 solubility in the mixed solvent of Shenhua coal liquefaction oil was tested first,then the capacity of predicting H_2 solubility in system was investigated by artificial neural network.The results showed that the calculation precision of neural network increased with the increase of cling times. For different mixed solvent,the relative error between calculated value and experimental value gradually decreased with the increase of hidden layer quantity.To reduce calculation amount,the hidden layer quantity were set as four.The maximum relative error of 3-4-1 network for solubility of hydrogen in different mixed solvent was 4.48%.The model could meet the need of predicting solubility of H_2.

关键词(KeyWords)： 溶解度;相平衡;人工神经网络;煤液化油模型组分混合溶剂
solubility;phase equilibrium;artificial neural network;mixed solvent of Shenhua coal liquefaction oil

Abstract:

Keywords:

基金项目(Foundation): 山西省科技攻关(工业)资助项目(20140321003-05);; 大同市科技攻关资助项目(201316)

作者(Author): 罗化峰
LUO Huafeng

DOI: 10.13226/j.issn.1006-6772.2016.04.024

参考文献(References)：

• [1]李克健,吴秀章,舒歌平.煤直接液化技术在中国的发展[J].洁净煤技术,2014,20(2):39-43.Li Kejian,Wu Xiuzhang,Shu Geping.Development of direct coal liquefaction technology in China[J].Clean Coal Technology,2014,20(2):39-43.
• [2]朱天星.氢气在煤液化油中溶解度的研究[D].太原:太原理工大学,2006.
• [3]罗化峰.氢气在煤液化油中的溶解规律及其在煤高温快速液化中作用研究[D].太原:太原理工大学,2011.
• [4]Luo H F,Ling K C,Zhang W S,et al.A model of solubility of hydrogen in hydrocarbons and coal liquid[J].Energy Sources,Part A:Recovery,Utilization,and Environmental Effects,2011,33(1):38-48.
• [5]罗化峰,郭剑虹,凌开成,等.氢气在烃类混合溶剂中高压溶解度的测定[J].煤炭转化,2011,34(2):55-58.Luo Huafeng,Guo Jianhong,Ling Kaicheng,et al.Determination on hydrocarbon mixtures at high pressures[J].Coal Conversion,2011,34(2):55-58.
• [6]Alvarez E,Riverol C,Correa J,et al.Design of a combined mixing rule for the prediction of vapor-liquid equilibria using neural networks[J].Industrial&Engineering Chemistry Research,1999,38(4):1706-1711.
• [7]Urata S,Takada A,Murata J,et al.Prediction of vapor-liquid equilibrium for binary systems containing HFEs by using artificial neural network[J].Fluid Phase Equilibria,2002,199(1/2):63-78.
• [8]Mohanty S.Estimation of vapour liquid equilibria of binary systems,carbon dioxide-ethyl caproate,ethyl caprylate and ethyl caprate using artificial neural network[J].Fluid Phase Equilibria,2005,235(1):92-98.
• [9]Mohanty S.Estimation of vapour liquid equilibria for the system carbon dioxide-difluoromethane using artificial neural network[J].International Journal of Refrigeration,2006,29(2):243-249.
• [10]Torrecilla J,Palomar J,Garcia J,et al.Modelling of carbon dioxide solubility in ionic liquids at sub and supercritical conditions by neural networks and mathematical regressions[J].Chemometrics&Intelligent Laboratory Systems,2008,93(2):149-159.
• [11]Teja A S,Gupta A K,Bullocka K,et al.Henry's constants of methanol in aqueous systems containing salts[J].Fluid Phase Equilibria,2001,185(1/2):265-274.
• [12]Chai X S,Falabella J B,Teja A S.A relative headspace method for Henry's constants of volatile organic compounds[J].Fluid Phase Equilibria,2005,231(2):239-245.
• [13]Alvarez E,Riverol C,Correa J M.Henry's constants of gases and volatile organic compounds in aqueous solutions[J].Fluid Phase Equilibria,2006,241(1/2):96-102.
• [14]Mani S,Hamid M,Mohsen M.Modeling the hydrogen solubility in methanol,ethanol,1-propanol and 1-butanol[J].Fluid Phase Equilibria,2010,289(1):22-39.
• [15]Mani S,Hamid M.Hydrogen solubility in heavy n-alkanes:modeling and prediction by artificial neural network[J].Fluid Phase Equilibria,2011,310(1/2):150-155.