神木烟煤流态化预热中煤气生成特性Gas generation characteristics of Shenmu bituminous coal in fluidized preheating
张震,朱建国,师永帅,王婷婷
ZHANG Zhen,ZHU Jianguo,SHI Yongshuai,WANG Tingting
摘要(Abstract):
预热燃烧具有燃料适应性广、负荷调节快及污染物排放低等优势,是一种新型的高效清洁燃烧技术。其中,煤粉流态化预热后产生的预热煤气既能反映预热过程中煤粉的改性程度,又对后续燃烧效率及NO_x排放有重要影响。因此,煤粉流态化预热后产生的预热煤气是控制燃料转化及低NO_x排放的关键。基于煤粉流态化预热转化过程,在温度可控的千瓦级煤粉预热燃烧试验平台上,研究了预热温度、循环流化床空气当量比、煤粉粒径对预热煤气生成特性的影响。结果表明,850~950℃,随预热温度升高,热解反应及气化反应增强,煤气中CO_2体积分数下降,CO体积分数增加,H_2体积分数先增加后不变,CH_4体积分数则先增加后减小,煤气品质改善,热值由2.86 MJ/m~3增至3.61 MJ/m~3;循环流化床空气当量比从0.3增至0.5时,氧化反应增强,煤气中CO_2体积分数增加,CO、H_2、CH_4体积分数降低,煤气热值由3.44 MJ/m~3降至2.04 MJ/m~3;随煤粉粒径增加,煤粉在提升管内停留时间延长,气化反应增强,煤气中CO_2体积分数降低,CO、H_2体积分数增加,CH_4体积分数先增加后减小,煤气热值由2.30 MJ/m~3增至3.63 MJ/m~3。
The preheating combustion is a novel effective and clean combustion technology with the technical advantages of wide fuel adaptability, high load adjustment and low pollutant emission. The preheating coal gas generated after the pulverized coal fluidization preheating can not only reflect the modification degree of the pulverized coal in a preheating process, but also play an important role in subsequent combustion efficiency and NO_x emission as well. Therefore, the preheating coal gas generated after the pulverized coal fluidization preheating is a key for controlling fuel conversion and low NO_x emission. Based on the pulverized coal fluidized preheating conversion process, the effects of preheating temperature, air equivalence ratio of CFB, and pulverized coal particle size on the preheated gas generation characteristics were investigated in this paper on a kW-stage pulverized coal preheating combustion experimental platform with controllable temperature. The results show that the pyrolysis and gasification reaction are enhanced with the increase of preheating temperature in the range of 850-950 ℃. The volume fraction of CO_2 in the gas decreases, the volume fraction of CO increases, the volume fraction of H_2 increases firstly and then remains unchanged, while the volume fraction of CH_4 increases firstly and then decreases. The gas quality is improved and the heat value increases from 2.86 MJ/m~3 to 3.61 MJ/m~3. When the air equivalent ratio of CFB increases from 0.3 to 0.5, the oxidation reaction is enhanced, the volume fraction of CO_2 in the gas increases, the volume fractions of CO, H_2 and CH_4 decreases, and the heat value of gas decreases from 3.44 MJ/m~3 to 2.04 MJ/m~3. With the increase of pulverized coal particle size, the residence time of pulverized coal in the riser is prolonged and the gasification reaction is enhanced. The volume fraction of CO_2 in the gas decreases, the volume fraction of CO and H_2 increases, the volume fraction of CH_4 increases first and then decreases, and the heat value of gas increases from 2.30 MJ/m~3 to 3.63 MJ/m~3.
关键词(KeyWords):
煤气生成特性;预热温度;循环流化床;空气当量比;粒径
gas generation characteristics;preheating temperature;circulating fluidized bed;air equivalence ratio;particle size
基金项目(Foundation): 中国科学院战略性先导科技专项资助项目(XDA21040100)
作者(Author):
张震,朱建国,师永帅,王婷婷
ZHANG Zhen,ZHU Jianguo,SHI Yongshuai,WANG Tingting
DOI: 10.13226/j.issn.1006-6772.21113001
参考文献(References):
- [1] 吕清刚,李诗媛,黄粲然.工业领域煤炭清洁高效燃烧利用技术现状与发展建议[J].中国科学院院刊,2019,34(4):392-400.LYU Qinggang,LI Shiyuan,HUANG Canran.Current situation and development suggestions of coal clean and efficient combustion technology in industry field[J].Bulletin of Chinese Academy of Sciences,2019,34(4):392-400.
- [2] BRYAN B,NESTER S,RABOVITSER J,et al.Methane de-NOx for utility PC boilers[R].[S.l.]:Institute of Gas Technology,2005.
- [3] RABOVITSER J,BRYAN B,KNIGHT R,et al.Development and testing of a novel coal preheating technology for NOx reduction from pulverized coal-fired boilers[J].Gas Separation and Purification,2003,1(2):4-8.
- [4] LIU C C,HUI S,ZHANG X L,et al.Influence of type of burner on NO emissions for pulverized coal preheating method[J].Applied Thermal Engineering,2015,85:278-286.
- [5] LIU C C,HUI S E,PAN S,et al.The influence of air distribution on gas-fired coal preheating method for NO emissions reduction [J].Fuel,2015,139:206-212.
- [6] LIU C C,HUI S E,PAN S,et al.Experimental investigation on NOx reduction potential of gas-fired coal preheating technology[J].Energy & Fuels,2014,28(9):6089-6097.
- [7] XIONG X H,LYU Z M,YU S L,et al.Coke preheating combus-tion study on NOx and SO2 emission [J].Journal of the Energy Institute,2021,97:131-137.
- [8] NIU Y Q,SHANG T,ZENG J,et al.Effect of pulverized coal preheating on NOx reduction during combustion[J].Energy & Fuels,2017,31(4):4436-4444.
- [9] 张海,贾臻,毛健雄,等.通过煤粉浓缩预热低NOx燃烧器实现高温空气燃烧技术的研究[J].动力工程,2008,28(1):36-39,107.ZHANG Hai,JIA Zhen,MAO Jianxiong,et al.Research on high temperature air combustion technology via primary air enrichment and preheating burner[J].Journal of Power Engineering,2008,28(1):36-39,107.
- [10] ZHANG H,YUE G,LU J,et al.Development of high temperature air combustion technology in pulverized fossil fuel fired boilers [J].Proceedings of the Combustion Institute,2007,31:2779-2785.
- [11] 吕清刚,朱建国,牛天钰,等.煤粉高温预热方法:CN101158468[P].2008-04-09.
- [12] ZHANG Y,ZHU J G,LYU Q G,et al.The ultra-low NOx emission characteristics of pulverized coal combustion after high temperature preheating [J].Fuel,2020,277:118050.
- [13] OUYANG Z,ZHU J,LU Q.Experimental study on preheating and combustion characteristics of pulverized anthracite coal [J].Fuel,2013,113:122-127.
- [14] YAO Y,ZHU J G,LU Q G,et al.Experimental study on preheated combustion of pulverized semi-coke [J].Journal of Thermal Science,2015,24(4):370-377.
- [15] ZHANG H,ZHANG Y,ZHU Z,et al.Circulating fluidized bed gasification of low rank coal:Influence of O2/C molar ratio on gasification performance and sulphur transformation [J].Journal of Thermal Science,2016,25(4):363-371.
- [16] 欧阳子区.无烟煤粉预热及其燃烧和污染物生成特性实验研究[D].北京:中国科学院研究生院(工程热物理研究所),2014.
- [17] IM-ORB K,SIMASATITKUL L,ARPORNWICHANOP A.Ana-lysis of synthesis gas production with a flexible H2/CO ratio from rice straw gasification [J].Fuel,2016,164:361-373.
- [18] LIU J P,ZHU Z P,JIANG H B,et al.Gasification of bituminous coal in a dual-bed system at different air/coal ratios [J].Energy & Fuels,2015,29(2):496-500.
- [19] 李超.烟煤流化床热解机理以及挥发产物组分分布特性研究[D].杭州:浙江大学,2016.
- [20] VALIN S,BEDEL L,GUILLAUDEAU J,et al.CO2 as a substitute of steam or inert transport gas in a fluidized bed for biomass gasification [J].Fuel,2016,177:288-295.
- [21] LEE W J,KIM S D,SONG B H.Steam gasification of an Australian bituminous coal in a fluidized bed[J].Korean Journal of Chemical Engineering,2002,19(6):1091-1096.
- [22] 石振,成帅,陈兆辉,等.神木烟煤热解产物分布及主要元素的迁移规律 [J].过程工程学报,2016,16(5):802-811.SHI Zhen,CHENG Shuai,CHEN Zhaohui,et al.Distribution ofproducts and migration of main elements during pyrolysis of Shenmu bituminous coal[J].The Chinese Journal of Process Engineering,2016,16(5):802-811.
- [23] MAN C,ZHU J,OUYANG Z,et al.Experimental study on combustion characteristics of pulverized coal preheated in a circulating fluidized bed[J].Fuel Processing Technology,2018,172:72-78.
- [24] DING H L,OUYANG Z Q,ZHANG X Y,et al.The effects of particle size on flameless combustion characteristics and NOx emi-ssions of semi-coke with coal [J].Fuel,2021,297:120758.
- 煤气生成特性
- 预热温度
- 循环流化床
- 空气当量比
- 粒径
gas generation characteristics - preheating temperature
- circulating fluidized bed
- air equivalence ratio
- particle size